Product ID:PRESTONE II ANTIFREZZE
MSDS Date:08/14/1997
FSC:6850
NIIN:01-252-8501
MSDS Number: BSVQZ

PRESTONE PRODUCTS CORPORATION

39 OLD RIDGEBURY ROAD
DANBURY, CT 06810-5109
US

Emergency Phone: 203-830-7800/800-424-9300(CHEMTREC)

Info Phone: 203-830-7800

Preparer: JAMES L OTTOWITZ

Cage: EO340

SILVER SALES

CALABASES, CA 91302 US

Telephone: 818-591-0788 WAS IN TX

Cage: 0WG65

ETHYLENE GLYCOL (SARA III)

CAS: 107-21-1

RTECS: KW2975000

Fraction By Weight: 80-95%

OSHA PEL C 50 PPM

ACGIH TLV: C 50 PPM,VAPOR; 9192

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

DIETHYLENE GLYCOL

CAS: 111-46-6

RTECS: ID5950000

Fraction By Weight: 0-8%

WATER

CAS: 7732-18-5

RTECS: ZC0110000

Fraction By Weight: 1-5%

NON-HAZARDOUS MATERIALS

Fraction By Weight: 10%

Routes of Entry: Inhalation:YES Skin:NO Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE & UPPER RESPIRATORY IRRITANT. MAY
CAUSE DEATH IF INGESTED/INHALED. SKIN CONTACT MAY CAUSE
DERMATITIS/SENSITIZATION. INHALATION: MAY CAUSE IRRITATION OF THE
NOSE & THROAT. EYES: MAY CAUSE CONJUNCTI VA. INGESTION: MAY CAUSE
CNS EFFECTS, PULMONARY EDEMA, SEVERE KIDNEY DAMAGE & WHICH MAY BE
FATAL.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION, NAUSEA, VOMITING, HEADACHE,
DROWSINESS, BLURRED VISION, CONVULSIONS, COMA, DISCOMFORT, REDNESS,
PAIN, MELAISE, DECREASE IN URINE OUTPUT, KIDNEY FAILURE, IRREGULAR
EYE MOVEMENTS, CARDIAC FA ILURE, WEAKNESS OF THE FACIAL MUSCLES,
DIMINISHING HEARING & DIFFICULTY SWALLOWING.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION: REMOVE TO FRESH AIR. IF BREATHING HAS STOPPED,
GIVE CPR. IF BREATHING IS DIFFICULT GIVE OXYGEN. SKIN: REMOVE
CONTAMINATED CLOTHING. WASH THOROUGHLY SOAP & WATER. EYES: FLUSH
W/LARGE AMOUNT S OF WATER. INGESTION: NEVER GIVE ANYTHING BY MOUTH
TO/ INDUCE VOMITING TO AN UNCONSCIOUS/DROWSY PERSON. OBTAIN MEDICAL
ATTENTION IN ALL CASES.

Flash Point Method:PMCC
Flash Point:220
Lower Limits:3.2
Upper Limits:15.3
Extinguishing Media:LARGE: USE ALCOHOL TYPE/ALL PURPOSE FOAMS. SMALL:
USE WATER SPRAY, CARBON DIOXIDE AND DRY CHEMICAL.
Fire Fighting Procedures:DON'T SPRAY POOL FIRES DIRECTLY. COOL FIRE
EXPOSED CONTAINERS W/WATER. FIREFIGHTERS SHOULD WEAR POSITIVE
PRESSURE SCBA & FULL PROTECTIVE CLOTHING.
Unusual Fire/Explosion Hazard:A SOLID STREAM OF WATER OR FOAM DIRECTED
INTO HOT, BURNING LIQUID CAN CAUSE FROTHING.

Spill Release Procedures:WEAR APPROPRIATE PROTECTIVE CLOTHING. COLLECT
W/ABSORBENT MATERIAL & PLACE IN APPROPRIATE LABELED CONTAINER FOR
DISPOSAL. PERMITTED FLUUSH AREA W/WATER.

Handling and Storage Precautions:DON'T DRINK ANTIFREEZE/SOLUTION. AVOID
EYE & REPEATED SKIN CONTACT. AVOID BREATHING VAPOR/MISTS. DON'T
STORE IN OPENED/ UNLABELED CONTAINERS.
Other Precautions:KEEP AWAY FROM OPEN FLAMES/EXCESSIVE HEAT. DON'T
REUSE EMPTY CONTAINERS UNLESS PROPERLY CLEANED.

Respiratory Protection:IF TLV IS EXCEEDED, USE NIOSH APPROVED
RESPIRATOR W/ORGANIC VAPOR CARTRIDES & DUST/MIST
PREFILTERS/SUPPLIED AIR RESPIRATOR.
Ventilation:USE GENERAL/LOCAL EXHAUST AS REQUIRED TO MAINTAIN EXPOSURE
BELOW TLV.
Protective Gloves:CHEMICAL RESISTANT: NEOPRENE/PVC
Eye Protection:SPLASH-PROOF GOGGLES
Other Protective Equipment:APPROPRIATE PROTECTIVE CLOTHING.
Work Hygienic Practices:REMOVE/LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE.
Supplemental Safety and Health
ORAL LD50 INFORMATION IS FOR ETHYLENE GLYCOL.NOTE TO PHYSICIAN: RAPIDLY
ACHIEVE & MAINTAIN BLOOD ETHANOL LEVEL OF 100MG BY MAINTENANCE
DOSE.

HCC:N1
Boiling Pt:B.P. Text:334F,168C
Melt/Freeze Pt:M.P/F.P Text:-8F,-22C
Decomp Temp:Decomp Text:NONE SPECI.
Vapor Pres:<0.1 @68F
Vapor Density:2.1
Spec Gravity:9.4 LBS/GAL
pH:NONE .
Evaporation Rate & Reference:<1 (BU ACETATE=1)
Solubility in Water:100%
Appearance and Odor:YELLOW, MILD ODOR.
Percent Volatiles by Volume:NONE

Stability Indicator/Materials to Avoid:YES
STRONG BASES AT HIGH TEMPS, STRONG ACIDS, STRONG OXIDIZING AGENTS &
MATERIALS REACTIVE WITH HYDROXYL COMPOUNDS.
Hazardous Decomposition Products:CARBON DIOXIDE, CARBON MONOXIDE.

Waste Disposal Methods:DISPOSE OF IAW/FEDERAL, STATE & LOCAL
REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.